Posted on

Front output hub parts needed!!!

Ok I have a 2007 Polaris sportsman 800 EFI (the later model) I just replace my sprag cage in the front differential when I noticed that the clutch discs on the output hubs no longer have the friction material sticking to them. I can’t find just the clutch discs anywhere, everywhere I have looked only sells the whole output hub assembly and it costs a lot of money. Does anyone know what I can do, where I can get just the clutch discs at? Please help
Posted on

Joel Hetrick Takes the Win at Ironman Raceway for Third Consecutive Year

Round four of the 2018 ATV Motocross National Championship (ATVMX) Series, presented by CST Tires, an AMA National Championship, was greeted by partly cloudy conditions with seasonal temperatures as the first moto’s broke off the gate Saturday, May 5. Ironman Raceway was in prime condition for the onslaught soon to be brought by the AMA Pro ATV riders.
Posted on

Compression

Ok So i have a 2010 800 Sportsman About 2000 Miles Ran Fine other than hitting water!
Found cracked plug wire!
Replaced plugs and wires Tried to Start and it backfired! (figured had wires backwards) Switched around wont start
Swapped out for old parts same issue
Done a Compression test 150 one side 75 on clutch side??? Ran fine before! Cleaned holes best i could
Not sure whats going on Any help be great thanks
Posted on

Bogs after water!

I have a 2008 Can Am Renegade 800 and after a little bit of water (like puddles, or splashing water) it starts to bog and gives it about half power, Im thinking it might be the coils getting wet. But it shouldn't happen. About 10-20 mins after being out of the water it runs fine again. Anyone know what's up with it?
Posted on

Fuel Guage Not Working

To anyone that has ever had this problem of your fuel gauge not work it is most likely the float had this problem forever, the guage reads empty all the time, you should take the fuel pump out and put the float up by hand to see if it will go up by hand, if it starts going up it is your float, easy fix and cost about $20, I get a float from this site http://stores.djstractorparts.com/fu...en-1-djsfloat/
Super cheap and works great, hopes this helps someone.
Posted on

question on 2015 rear diff

had a leaking seal pulled diff to replace seal and noticed a lot of play on the peice that goes onto shaft, wondering if a rear diff rebuild is the way to go, i am seperating diff today to look more into jus looking for some opinions i am still new to the renegade
Posted on

Sportsman 500 HO won’t stay running

I have a 08 Sportsman 500 ho. Starts and runs good for about 10-15 minutes then dies and won't start. If you let it set/ cool down for a little while it will start and run then die again. Spark plug is brand new. Could it be the Coil?

Thanks
Posted on

Sportsman 500 HO won’t stay running

I have a 08 Sportsman 500 ho. Starts and runs good for about 10-15 minutes then dies and won't start. If you let it set/ cool down for a little while it will start and run then die again. Spark plug is brand new. Could it be the Coil?

Thanks