Category: Forum News

I wondered if anyone knew if oil is supppsed to be able to get into the 4wd acuator housing or is there a seal out around the front output shaft

They are marked 26x9x14 and 26x11x14 but in fact are 1 inch smaller in each dimension when properly inflated.

They have (3) stars on them indicating 6 ply, and are stamped max pressure of 7 lb.

I have only driven them a couple miles in 45 degree temps and have a lot of wobble. Perhaps they will smooth out after they warm up.

I am guessing that even if I get the same size tire in any other brand they are going to be at least and inch larger in ever direction. Not sure who makes a 26 inch tire that is really 25 for instance.

Anyone want to part with one?? I will take care of the shipping.

Brand new 2017 touring 1000. Got it home, went to ride, EPS light came on would not operate. Ran it for a few minutes, restarted works fine. My guess is the battery was too low and the EPS was disabled.

Been out of town for 3 days. Came home and checked the resting voltage it is at 11.5 when I turn the key to "on". What should it be? Will Polaris warranty the batt on a brand new machine?

Thanks,

Recently my 2002 polaris sportsman 500 ho has developed a stutter at around half throttle. It will sometimes be able to break over it and sometimes it will just get stuck on that certain rpm. I've checked the cam, adjusted valves, replaced cdi box, cleaned and adjusted carb, replaced spark plug and nothing seems to fix it. Any ideas?

Have a fellow employee and friend who is getting rid of some of his dads stuff from an Alzheimer’s issue. He has a 2003 Polaris sportsman 500. His dad bought it new for the hunt club which he was only in for 2-3 years then it mainly sat, and hasn’t been used in years since then. I went and looked at it today, battery was dead but hooked up to a battery starter/charger it powered up awesome, had good compression and a strong starter. I could not get it to turn over as I believe there is bad gas and a gummed up carb. The camo is faded, but in good solid condition otherwise. Not broke or damaged. If I buy this what should I expect to pay, what should I do besides oil and gas, is the belt an issue, anything else I should look for?

Please excuse the mess, I was told his dad kept an immaculate garage till Alzheimer’s started kicking his ass.

The seats not even torn, tires still look good

Attached Thumbnails

   

I just bought a 15 xmr and it has snorkel extensions on it and I'm wanting to return it to the factory xmr snorkels but I'm not sure if they've been cut or what is there anyway to get a parts diagram for it to see if they have?

What years are the gen 1 outlander plastics different? Are they interchangeable?

Sent from my XT1585 using Tapatalk

I put 27 inch mudlites on my hd5 and Obviously the power is down in high range. I was trying to find a clutch kit but no luck. Any suggestions?? Anyone else have the same problem and find a good solution?

2012 1000 xt outlander I get a clunk when i take of sounds like in front drive shaft .....any help?