Posted on

2017 Sportsman XP 1000 Sway bar problem!

Got a problem with my sway bar and wanted to know if any of you had the same problem. My sway bar shifted a bit to the right, so doesnt sit perfectly in the middle.( So off set to the right) It also rubs a bit on the left coil spring because of this. I chamged the bushings, and even bought a new sway bar...no change still shifted. Dont know if this is normal or not??
Posted on

Hi Yall

I was given a 04 Sportsman 700 EFI baskets case and it was missing some parts.
If got the motor running but have a code 51. I installed reman. injectors from Ebay can afford $550 for new. New plugs and fuel pump. New crank sensor.
I've checked all of the wires and plugs, cleaned and repaired any problems and used an ohms meter to check for short's. I don't know where to turn and could use some help.
I said it runs but won't hold an idle and use the throttle cable adjustment to keep it running.
Thanks
Posted on

Help Identify Noise

I am new to the Can-am scene and I have a 650 6x6 that so far I really love. I've only got a few hundred miles on it and am hoping for some help with a noise that I don't know if it is normal or something I need to look into. When in 6x6 there is a noise that sounds kind of like a tire noise or like there is a stick rubbing on the tread of a tire. Kind of hard to describe. It's not super loud and the faster you go the louder it is, like 10-15 mph. When i switch back into 4x4 mode, which also takes quite a while to go back into 4x mode, the noise goes away. Is this a normal noise? If not, any ideas?
Posted on

idle issues 02 trailboss 325

Hey guys, So my 02 Polaris trailboss 325 has some issues with idle. Its kind of a pain to get started on colder days even with the choke out. but when it starts it idles but then will die and its easy to start after that I just have to babysit it til its warm then it idles fine. The main problem is after riding it for quite sometime and its hot it idles really high. it idles high enough its hard to get into gear and really grinds when it goes into gear. So when it gets hot I reach under (and try not to burn the living hell out of my hand) and adjust the idle screw and then its fine. But when it sits for quite sometime and gets cool again the idle is too low. Any ideas for the new guy?
Posted on

2007 Polaris sportsman Issue

OK getting desperate here..... 2007 polaris sportsman 500 efi........ starts fine cold....... after riding a bit will stall out when you let off the throttle and have trouble starting after riding for an hour...... cranks fine just wont turn over or idle unless I sit o the throttle....... flashes codes 22,41,46,56,58......and just starting to flash the Battery icon. changed the fuel filter and cleaned up the map sensor and battery has plenty of juice ....... sometimes after it's warm it will stall out and backfire after i get it started. any ideas?
Posted on

new headlight problems

hey guys I have 2002 sportsman 500 ho. I bought some led 4inch pods and would like to install them as new headlights but I ran into a problem my pods have a 2 wires 1 negative and 1 positive while my headlight harness as 3 wires 1 negative and 2 positive wires for my high/low is there anyway I can hook my new pods up to both high/low or just one or the other